Product ID:NOX RUST 509
MSDS Date:03/05/2000
FSC:8030
NIIN:00-231-2353
Status Code:A
MSDS Number: CLHZS

RALRUBE INC.

36977 FOX GLEN
FARMINGTON HILLS, MI 48331
US

Emergency Phone: (800)424-9300

Info Phone: 248-661-0260

Preparer: HENRY SIMMONS

Cage: 6X798

RALRUBE INC.

FARMINGTON HILLS, MI 48331 US

Telephone: 248-661-0260, FAX 248-661-3941

Cage: 6X798

PETROLEUM OIL

CAS: 64741-96-4

RTECS: PY8040000

ACGIH TLV: 5 MG/M3

PETROLATUM

CAS: 8009-03-8

RTECS: SE6780000

OSHA PEL 2 MG/M3

ACGIH TLV: 2 MG/M3

PARAFFIN WAX 115

CAS: 8002-74-2

RTECS: RV0350000

ACGIH TLV: 2 MG/M3

Health Hazards Acute and Chronic:ACUTE EFFECTS: MAY CAUSE SEVERE
IRRITATION AND REVERSIBLE SKIN IRRITATION. PROLONGED SKIN EXPOSURE
MAY DERMATITIS OR OIL ACNE. BREATHING MISTS MAY CAUSE PULMONARY
IRRITATION OF DIZZINESS. EXCESSIVE IN HALATION MAY PRODUCE
DIZZINESS, NAUSEA, HEADACHE, AND INCOORDINATION.
Medical Cond Aggravated by Exposure:EXPOSURES MAY AGGRAVATE
PRE-EXISTING RESPIRATORY OR SKIN PROBLEMS.

First Aid:INHALATION: MOVE VICTIM TO FRESH AIR AND CALL EMERGENCY
MEDICAL CARE. IF NOT BREATHING, GIVE ARTIFICIAL RESPIRATION. IF
BREATHING IS DIFFICULT, GIVE OXYGEN. EYES: IN CASE OF CONTACT WITH
MATERIAL, IM MEDIATELY FLUSH EYES WITH RUNNING WATER FOR AT LEAST
15 MINUTES. SEEK IMMEDIATE MEDICAL ATTENTION. SKIN: WASH SKIN WITH
SOAP AND WATER. REMOVE AND ISOLATE CONTAMINATED CLOTHING AND SHOES
AT THE SITE. INGESTION: DO NOT INDUCE VOMITING. CONSULT A
PHYSICIAN. IF VOMITING OCCURS SPONTANEOUSLY, KEEP HEAD BELOW HIPS
TO PREVENT ASPIRATION INTO THE LUNGS.

Flash Point:=148.9C, 300.F
Extinguishing Media:SMALL FIRES: DRY CHEMICAL, CO2, WATER SPRAY, OR
REGULAR FOAM. LARGE FIRES: WATER SPRAY, FOG, OR REGULAR FOAM. MOVE
CONTAINER FROM FIRE AREA IF YOU CAN DO IT WITHOUT RISK.
Fire Fighting Procedures:FIRE MAY PRODUCE IRRITATING OR POISONOUS
GASES. POSITIVE PRESSURE SELF-CONTAINED BREATHING APPARATUS (SCBA)
AND STRUCTURAL FIREFIGHTERS? PROTECTIVE CLOTHING WILL PROVIDE
LIMITS PROTECTION. KEEP UNNECE SSARY PEOPLE AWAY. ISOLATE HAZARD
AREA AND DENY ENTRY. STAY UPWIND; KEEP OUT OF LOW AREAS. ISOLATE
FOR ? MILE .
Unusual Fire/Explosion Hazard:FLAMMABLE/COMBUSTIBLE MATERIAL. MAY BE
IGNITED BY HEAT, SPARKS, OR FLAMES. VAPORS MAY TRAVEL TO A SOURCE
OF IGNITION AND FLASH BACK CONTAINER MAY EXPLODE IN HEAT OF FIRE.
VAPOR EXPLOSION HAZARD INDOOR S, OUTDOORS, OR IN SEWERS. RUNOFF TO
SEWER MAY CREATE FIRE OR EXPLOSION HAZARD.

Spill Release Procedures:SHUT OFF IGNITION SOURCES; NO FLARES; SMOKING
OR FLAMES IN HAZARD AREA. STOP LEAK IF YOU CAN DO IT WITHOUT RISK.
SMALL SPILLS: TAKE UP WITH SAND OR OTHER NONCOMBUSTIBLE ABSORBENT
AND PLACE INTO CONTA INERS FOR LATER DISPOSAL. LARGE SPILLS: DIKE
FAR AHEAD OF LIQUID SPILL FOR LATER DISPOSAL.

Handling and Storage Precautions:STORE IN COOL, WELL-VENTILATED AREA.
KEEP AWAY FROM FLAMES, SPARKS OR HOT SURFACES. NEVER USE A TORCH TO
CUT OR WELD ON OR NEAR CONTAINER. EMPTY CONTAINER CAN CONTAIN
EXPLOSIVE VAPORS.
Other Precautions:NEVER WEAR CONTAMINATED CLOTHING. LAUNDER OR DRY
CLEAN AREA BEFORE WEARING. DISCARD OIL-SOAKED SHOES. WASH
THOROUGHLY WITH SOAP AND WATER (WATERLESS HAND CLEANER MAY BE
HELPFUL IN REMOVING IN REMOVING RESIDUES) AFTER USE AND BEFORE
SMOKING OR HEATING. AVOID EXCESSIVE SKIN CONTACT.

Respiratory Protection:NIOSH-APPROVED RESPIRATOR FOR ORGANIC VAPOR AND
TO MIST TO CONTROL EXPOSURE WHERE VENTILATION IS INADEQUATE.
Ventilation:GENERAL AND LOCAL EXHAUST.
Protective Gloves:IMPERVIOUS GLOVES (VITON, PVOH, ETC)
Eye Protection:SAFETY GLASSES WITH SIDESHIELDS OR CHEMICAL GOGGLES.
Other Protective Equipment:IF SPLASHING IS ANTICIPATED, WEAR RUBBER
APRON AND BOOTS OR OTHER PROTECTIVE EQUIPMENT TO MINIMIZE CONTACT.
Supplemental Safety and Health

Boiling Pt:>148.9C, 300.F
Vapor Pres:<1
Vapor Density:>1
Spec Gravity:0.9
VOC Grams/Liter:.2
Evaporation Rate & Reference:>1 (BUTYL ACETATE=1)
Solubility in Water:NEGLIGLBLE
Appearance and Odor:DARK AMBER, SOFT WAXY SOLID WITH A PETROLEUM OIL
ODOR.
Percent Volatiles by Volume:<0.5

Stability Indicator/Materials to Avoid:YES
STRONG ACIDS, OXIDIZING AGENTS
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
OXIDES OF SULFUR, MISCELLANEOUS HYDROCARBONS.

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH STATE, LOCAL AND
FEDERAL REGULATIONS. MATERIALS MAY BECOME HAZARDOUS WASTE THROUGH
USE. IF PERMITTED, INCINERATION MAY BE PRACTICED.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.